Results 1 to 3 of 3

Thread: Smokin' ... NO Literally

  1. #1
    Master Browser PeteSmith's Avatar
    Join Date
    Aug 2004
    Location
    LV-426
    Posts
    661
    Thanks
    44
    Thanked
    45 times in 42 posts
    • PeteSmith's system
      • Motherboard:
      • ABIT IP35 Pro
      • CPU:
      • Q6600 G0
      • Memory:
      • 4x1GB 8500 Crucial Ballistix
      • Storage:
      • System: Crucial 128GB M4 SSD Storage: 2x500GB WD5000AAKS
      • Graphics card(s):
      • GTX 650
      • PSU:
      • Corsair HX 620
      • Case:
      • Antec P182
      • Operating System:
      • Windows 10
      • Monitor(s):
      • Dell 2407WFP-HC

    Smokin' ... NO Literally

    You know that awful smell we all dread, the kinda melted plastic - burnt hair mix that usually means disaster and follows by that sharp pain in your wallet. Well unfortunately i encountered it this bank holiday weekend, which kinda started things off badly.

    I'm not really sure how this happened, as i have not been inside my case for a good long time, but it turns out that the case speaker wire had somehow sheared off and made contact between the case and the live wire, which in turn completely melted the wire, and subsequently many of the other wires within close proximity. In fact the only one left intact was the power switch lead and the H.D.D led wire. Not only had it melted the wires but also completely melted the mobo contacts.

    I was initially concerned the mobo would have been damaged, which in turn could have taken out other components, which was only heightened when i attempted to power up and the machine continually reset itself in quick succession and was accompanied by a HDD clicking noise.

    After an hours worth of open case surgery, removing melted wires, replacing the ones i had spares for and strategically unit testing each component to check they were still working without risking further damage (and generously applying electrical tape to existing wires which were slightly damaged from contact- just to be sure) i finally managed to to restore life to the old dog.

    I learnt 2 things from this exercise:

    1. Fires are best left outside of PC cases, because they tend to melt things and smell terrible.
    2. PC's and components these days are much more resilient than i had previously thought.

    I really did expect the worse this time, and imagined i would need to purchase my new rig a little earlier than i had planned, luckily i got a 2nd chance which means i can buy that new mountain bike i have been drooling over first.





    Last edited by PeteSmith; 27-08-2007 at 04:10 PM.
    Main PC : Abit IP35-Pro | Q6600 G0 @ 3GHz | 4x1GB Crucial Ballistix 8500 | MSI N460 GTX HAWX | 1 x Crucial M4 128GB SSD | Antec 182 | Corsair HX620 | Dell 2407WFP-HC | Windows 10 x64
    Server : HP MicroServer N40L | 16 GB RAM | 4 X 1 GB Samsung Spinpoint F1 | ESXi 6.0 NAS : Synology DS-408 - 4 x 3GB WD RED HTPC : Acer Revo RL70 | LibreElec

  2. #2
    root Member DanceswithUnix's Avatar
    Join Date
    Jan 2006
    Location
    In the middle of a core dump
    Posts
    12,978
    Thanks
    778
    Thanked
    1,586 times in 1,341 posts
    • DanceswithUnix's system
      • Motherboard:
      • Asus X470-PRO
      • CPU:
      • 5900X
      • Memory:
      • 32GB 3200MHz ECC
      • Storage:
      • 2TB Linux, 2TB Games (Win 10)
      • Graphics card(s):
      • Asus Strix RX Vega 56
      • PSU:
      • 650W Corsair TX
      • Case:
      • Antec 300
      • Operating System:
      • Fedora 39 + Win 10 Pro 64 (yuk)
      • Monitor(s):
      • Benq XL2730Z 1440p + Iiyama 27" 1440p
      • Internet:
      • Zen 900Mb/900Mb (CityFibre FttP)

    Re: Smokin' ... NO Literally

    I had that rebuilding mother-in-law's PC once. The little wire going to the speaker cone came off and shorted to the frame, which of course is jammed into the case and so earthed.

    One side of the speaker is +5v, the other is usually grounded by a transistor to make it beep. Result can be +5v directly to ground via that little wire, and my god what a lot of smoke!

    I was lucky and caught mine fast, a new speaker and the system was fine.

  3. #3
    Pedandic mo-fo IAmATeaf's Avatar
    Join Date
    Jul 2006
    Location
    South of the Watford Gap!
    Posts
    963
    Thanks
    2
    Thanked
    22 times in 22 posts
    • IAmATeaf's system
      • Motherboard:
      • Asus P5Q Deluxe
      • CPU:
      • Q6600@3.25
      • Memory:
      • 4 x 2GB Corsair 6400C5DHX XMS2
      • Storage:
      • 2 x 0.5TB 7200.12, 2 x 1.5TB 7200.11
      • Graphics card(s):
      • Gigabyte GTX460 OC
      • PSU:
      • Corsair HX520
      • Case:
      • Lian Li PC6089B
      • Operating System:
      • Windows 7 Pro x64
      • Monitor(s):
      • Samsung T240 24"
      • Internet:
      • 6Mb ADSL Max

    Re: Smokin' ... NO Literally

    I'd replace the entire length of wire that melted and caused the problem, no point in taking any further risks.

Thread Information

Users Browsing this Thread

There are currently 1 users browsing this thread. (0 members and 1 guests)

Similar Threads

  1. FEAR - quite literally
    By IBM in forum Gaming
    Replies: 19
    Last Post: 14-06-2007, 09:28 AM
  2. Quite literally raging.
    By Robert in forum Graphics Cards
    Replies: 17
    Last Post: 20-03-2006, 09:04 PM
  3. Blue Screen (quite literally)
    By Howard in forum Software
    Replies: 4
    Last Post: 01-04-2004, 06:31 PM
  4. Heatsink ...quite literally AMAZING and its CHEAP
    By Zak33 in forum PC Hardware and Components
    Replies: 21
    Last Post: 03-12-2003, 07:01 PM

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •